只要除铁器不发生故障，平时的检查维护主要是经常对其周围的粉尘进行除净清理，对轴承定期加油。

As long as the iron is not broken down, the usual inspection and maintenance is mainly to clean up the dust around it, and refuel regularly on the bearing.

2、除更换电源线外，无特殊情况，请不要随意打开出线盒盖，以免引起绝缘线圈老化。更换电源线时（请用同一规格的电缆线），打开接线盒盖后请注意充分干燥、牢靠接线。拧紧所有螺栓，恢复原来状态。

2, in addition to the replacement of the power supply line, there is no special situation, please do not open the wire box cover at will, so as to avoid the insulation coil aging. When replacing the power line (please use the same cable), please pay attention to the full dry and reliable connection after opening the connection box cover. Tighten all bolts to restore the original state.

3、卸铁皮带和电源线要定期检查，发现外伤，应及时更换。

3, the iron belt and the power line should be checked regularly, and the injury should be changed in time.

4、减速机使用说明：

4. The description of the use of the reducer:

(1)减速机采用摆线针齿啮合、行星式传动原理，减速机额定转速为1480转/分，允许正反两个方向运转；

(1) the reducer adopts the principle of cycloid pin tooth meshing and planetary transmission, and the rated speed of the reducer is 1480 rpm, allowing the positive and negative two directions to run.

(2)减速机在正常情况下采用油池润滑，油面高度保持在视窗的中部即可，润滑油建议采用E90#极压齿轮油，也可用40#、50#机油代用。加油时旋开基座上部的通风帽即可加油，放油时旋开机座下部的放油塞，即可放出污油。

(2) under the normal condition, the reducer is lubricated by oil pool, and the oil surface height is kept in the middle of the window. The E90# extreme pressure gear oil is recommended for lubricating oil, and the substitution of 40# and 50# oil can also be used. The gas cap on the upper part of the base can be refueling when the fuel is refueling, and the oil can be released when the oil is placed in the lower part of the screw opening seat.

(3)第一次加油运转100小时即应更换新的润滑油（并将内部污油冲净），以后连续工作每半年更换一次（8小时工作制）。如工作条件恶劣，则应缩短换油时间。

(3) the first time of refueling and running for 100 hours, the new lubricating oil should be replaced (and the internal dirty oil should be washed away). After that, it will be renewed every half a year (8 hours). If the working conditions are bad, the oil changing time should be shortened.

(4)使用过程中应经常补充润滑油。

(4) the lubricating oil should be often supplemented during the use.